Thursday, August 27, 2009

Smile and say cheese!

I feel like dancing a jig, blowing a horn or jumping up and down. I made mozzarella cheese on my first try and I am ridiculously happy.

If you have ever wanted to make your own cheese but thought it would be too hard, too complicated or take too long, stop thinking about it and make some cheese.

The whole process took less than 45 minutes, start to finish, and was easier than making pancakes.

Once you have the rennet and the citric acid, all you need is a gallon of milk, salt to taste, a thermometer and a microwave.

The recipe I followed was from the New England Cheesemaking Supply Company:



1 gallon of whole milk (not ultra pasteurized)

1 1/2 level tsp of citric acid, dissolved in 1/4 cup cool water

1/4 tsp liquid vegetable rennet, diluted in cool water


Dissolve the citric acid in water in a small glass or plastic cup and set aside. Dilute the rennet in a small glass or plastic cup and set aside.
Pour the milk into an 8 quart stainless steel pot and heat slowly until it reaches a temperature of 55 degrees then add the citric acid solution and stir thoroughly. I used a stainless steel whisk for this.

When the milk reaches 88 degrees, it will begin to curdle

Pour in the rennet and fold it in with gentle scooping motions.

Continue heating until the temperature reaches just over 100 degrees.

At this point, the curds should be pulling away from the edge of the pot and the whey should look clear, not cloudy.

Use a slotted spoon to remove the curds from the pot and place them in a two quart microwaveable bowl.
Press the curds gently with your hands to remove as much hey as possible - this takes a few minutes.

Microwave the curds for 1 minute on high then knead the cheese with your hands or the back of a spoon to remove more whey.

Microwave two more times for 35 seconds, kneading the curds each time to remove more whey. At this point, add salt to taste.
Remove the cheese from the bowl and knead and pull it until it is smooth and elastic. If it starts to break apart, reheat for another 35 seconds.

When the curds can be stretched like taffy, the cheese is finished and can be rolled into one large ball or several small balls. The mozzarella can be eaten right away warm or stored in the refrigerator for up to a week.

Don't discard the whey. You can use it to make ricotta cheese later.


Emily said...

That's so freaking cool. Now I want to do it. How did your lasagna turn out? Does it taste better than the store stuff? That's so exciting!

Jill said...

It was fun - you'd like making it... it's like playing with Play Doh, sort of.

I made a pizza with semolina cust with the flour you broght me.

I'll post that recipe later. You would like it.. the crust was very crispy.

I saved the whey and plan to make another batch of mozzarella for lasagna. It takes quite a lot of whey to make ricotta. I have another recipe for whole milk ricotta in case the first one fails or it doen't make enough for the lasagna.
If you were here we could go into production - making cheese and rolling out pasta dough.

I miss you.

Anonymous said...

A good story

GK Chesterton: “The poets have been mysteriously silent on the subject of cheese.”

Voila: This book is a poetic view of 30 of the best loved French cheeses with an additional two odes to cheese. Recipes, wine pairing, three short stories and an educational section complete the book.

From a hectic life in New York City to the peace and glories of the French countryside lead me to be the co-founder of Ten years later with the words of Pierre Androuet hammering on my brain:

“Cheese is the soul of the soil. It is the purest and most romantic link between humans and the earth.”

I took pen and paper; many reams later with the midnight oil burning Tasting to Eternity was born and self published.

I believe cheese and wine lovers should be told about this publication.